electrical specifcations input voltage range: 347-480 nom. vac (312-512 v min/max) frequency: 50/60 hz nom. (47-63 hz min/max) power factor: >0.90 @ 75-100% load, 347-480v inrush current: 20 amps max @ 480vac, cold start 25oc input current: 0.70a max @ 347vac, 0.42a max @ 480vac maximum power: 150w line regulation: 1% load regulation: 3% thd: <_ 20% @ 75-100% load, 347-480v leakage current: 1 ma @ 480vac, 60hz typical effciency 89-91% at 347vac turn-on delay: 1s max protection: over-voltage, over-temperature (105c), and short circuit protection environmental specifcations minimum starting temp: -40oc storage temperature: -40oc to +85oc humidity: 5% to 100% cooling: convection sound rating: class a mtbf: 250,000 hours @ 480vac input, 80% load and 25oc ambient conditions per mil-hdbk-217f lifetime: 145,700 hours @ 480vac, 80% load and 45oc ambient weight: 2.87 lbs. (1300g) vled-150w-hv series 347-480v input, fixed & dimmable output switch mode led drivers constant current with isolation aluminum housing constant current - product specifcations model number output current (ma 5%) output voltage range (vdc) max. output power (w) typical effciency vled150w-258-c0580- x -hv 580 129-258 150 91% vled150w-214-c0700- x -hv 700 107-214 150 91% vled150w-142-c1050- x -hv 1050 71-142 150 90% vled150w-107-c1400- x -hv 1400 53-107 150 90% vled150w-071-c2100- x -hv 2100 36-71 150 90% vled150w-054-c2800- x -hv 2800 27-54 150 90% vled150w-043-c3500- x -hv 3500 21-43 150 89% vled150w-036-c4200- x -hv 4200 18-36 150 89% ordering options: -d: 0-10v dimmable version comes with an extra three wires purple/gray/blk-wht on the output side. dimming is compatible with most quality 0-10v wall dimmers and direct 0-10v analog signal. see page 3 for additional specifcations. -x indicates dimming options are available. see options at left. blank = fxed current output e332160 ? total power: 150 watts ? input voltage: 347-480 vac nom. ? ul dry & damp location rated ? ip67 ? high power factor ? ul8750, en61347 rev 8-25-15 specifcations subject to change without notice. note: led drivers are designed and intended to operate led loads only. non-led loading may be outside the specifed design limits of our led drivers, and therefore cannot be covered by any warranty. if you desire to use our led drivers to operate non-led loads please contact us to discuss compatibility. thomas research products ? 1225 bowes rd ? elgin, il 60123 ? t 847-515-3057 ? f 847-515-3047 ? www.trpssl.com
pg 2 of 4 dimensions - mm output red (+) blue (-) input black (l) white (n) green (gnd) output red (+) blue (-) input black (l) white (n) green (gnd) dimming black/white (vaux) purple (+) gray (-) wire specs: ac input: ul stw #18awg dc output: ul sjtw #18awg dimming: ul2426 #22awg 65020 23020 30020 505 4.4 ?9.50.2 ?9.5 305 405 505 152 505 152 23020 505 152 51 188 43.5 38 86 88 93.9 43.5 38 86 88 93.9 70 65020 505 ?9.50.2 ?7.30.2 152 70 9.5 45 17.5 4.4 ?9.5 9.5 45 17.5 184 106 tc=90c 20 222 202 188 184 222 202 safety and emc compliance ul/cul ul8750, ul1012, ul935, csa-c22.2 no. 107.1-01 fcc part 15 ansi c63.4:2009 class b vled150w-hv series thomas research products ? 1225 bowes rd ? elgin, il 60123 ? t 847-515-3057 ? f 847-515-3047 ? www.trpssl.com ssl solutions faster than the speed of light ?
pg 3 of 4 -d option: - 0-10vdc dimming notes: 1. the dimmer can also be replaced by an active 0-10v voltage source signal or passive components like resistors and zener. 2. the dimming signal is allowed to be less than 1v, when it is between 0 and 1v, the output level is 10%. 3. do not connect the gray wire (vdim-) to blue wire (v-) together. 4. the dimming section is not isolated with output. 5. if 0-10v dimming is not used, dim + can be either open or connected to vaux. parameters minimum typical maximum 12v output voltage (vaux) 10.8 v 12 v 13.2 v 12v output source current 0 ma 20 ma absolute maximum voltage on the 0-10v input pin -20 v 20 v source current on 0-10v input pin 100 a 140 a 250 a external resistor dim+ (purple) vaux (yellow) rx 1k ohm dim- (gray) dimming voltage (v) normalized output current normalized output current output current / dimming voltage 0% 20% 40% 60% 80% 100% 0 1 2 3 4 5 6 7 9 8 10 rx (k?) output current / rx 0% 20% 40% 60% 80% 100% 0 10 20 30 40 50 60 70 90 80 100 dim+ (purple) v+ (red) l n g v- (blue) vaux (wht/blk) 0-10v wall dimmer dc input vled150w-xxx-cxxxx-d-hv l n g vled150w-xxx-cxxxx-d-hv dim- (gray) 30 case temperature (c) lifetime (khrs) lifetime / case temperature 0 30 60 90 120 165 15 45 75 105 150 135 35 40 45 55 60 65 70 80 50 75 85 90 derating curve load (%) 100 80 60 40 20 0 ambient temperature (c) -40 -30 -20 -10 0 10 20 30 40 50 60 70 vled150w-hv series thomas research products ? 1225 bowes rd ? elgin, il 60123 ? t 847-515-3057 ? f 847-515-3047 ? www.trpssl.com ssl solutions faster than the speed of light ?
pg 4 of 4 580ma model 700 ma model 1050ma model 50% normalized output voltage efficiency 75% 70% 80% 85% 90% 95% 75% 70% 80% 85% 90% 95% 75% 70% 80% 85% 90% 95% 75% 70% 80% 85% 90% 95% 75% 70% 80% 85% 90% 95% 75% 70% 80% 85% 90% 95% 75% 70% 80% 85% 90% 95% 75% 70% 80% 85% 90% 95% 60% 70% 80% 90% 100% efficiency / load 50% normalized output voltage efficiency 60% 70% 80% 90% 100% 347v a c 480v a c 347v a c 480v a c 347v a c 480v a c 347v a c 480v a c 347v a c 480v a c 347v a c 480v a c 347v a c 480v a c 347v a c 480v a c 50% normalized output voltage efficiency 60% 70% 80% 90% 100% 1400ma model 2100ma model 2800ma model 50% normalized output voltage efficiency 60% 70% 80% 90% 100% 50% normalized output voltage efficiency 60% 70% 80% 90% 100% 50% normalized output voltage efficiency 60% 70% 80% 90% 100% 3500ma model 4200ma model 50% normalized output voltage efficiency 60% 70% 80% 90% 100% 50% normalized output voltage efficiency 60% 70% 80% 90% 100% 50% normalized output voltage pf power factor / output voltage (700ma) 60% 70% 80% 90% 100% 50% normalized output voltage thd thd / output voltage (700ma) 60% 70% 80% 90% 100% 347v a c 480v a c 347v a c 480v a c 0.60 0.65 0.80 0.75 0.70 0.85 0.95 0.90 1.00 0% 15% 10% 5% 20% 25% vled150w-hv series thomas research products ? 1225 bowes rd ? elgin, il 60123 ? t 847-515-3057 ? f 847-515-3047 ? www.trpssl.com ssl solutions faster than the speed of light ?
|
